HVAC System Fault Analysis Cases

Detailed HVAC system diagnostics including air conditioning failures, heating system problems, and ventilation issues.

Browse by Specific Problem

2004 Jeep Wrangler Hardtop Wiring Issue
2004 Jeep Wrangler
The owner recently purchased a hardtop and a Mopar wire kit for their 2004 Jeep Wrangler. After following installation instructions closely, they foun...
Jeep Wrangler hardtop
View Analysis →
1976 Jaguar Sovereign Ball Joint Replacement Issue
1976 Jaguar Sovereign
The owner of a 1976 Jaguar Sovereign is facing difficulties with a stuck tapered fit ball joint. They inquired about using a ball joint splitter and m...
Jaguar Suspension Ball Joint
View Analysis →
2000 Lincoln LS Severe Coolant Leak Diagnosis
2000 Lincoln LS
The owner of the 2000 Lincoln LS reports a severe coolant leak causing the car to overheat quickly, only being able to drive half a mile before requir...
coolant_leak Lincoln_LS overheating
View Analysis →
Buick Century 3.3L V6 Hesitation Issues Diagnosis
unknown Buick Century
The owner reports intermittent hesitation in their Buick Century 3.3L V6, occurring at various times, both cold and hot. They have replaced the IAC, T...
Buick Century hesitation
View Analysis →
1996 Subaru Outback Head Gasket Replacement Procedure
1996 Subaru Outback
The vehicle owner reports that the 1996 Subaru Outback has been experiencing overheating issues, with a noticeable loss of coolant and white smoke ema...
Subaru head gasket overheating
View Analysis →
AC Recirculation Issue in 2000 Toyota 4Runner
2000 Toyota 4Runner
The owner of a 2000 Toyota 4Runner reports that fresh air is continuously entering the cabin, even when the AC and fan are turned off, and the air is ...
Toyota 4Runner AC System
View Analysis →
1997 Cadillac Deville HVAC Front Vent Issue
1997 Cadillac Deville
The owner reports no air is coming out of the front dash vents in their 1997 Cadillac Deville. They replaced the air flow actuator located under the g...
Cadillac HVAC air flow actuator
View Analysis →
1998 Oldsmobile Intrigue Overheating and Cold Air Issue
1998 Oldsmobile Intrigue
The owner of a 1998 Oldsmobile Intrigue reports that the vehicle blows cold air when the heater is on and also experiences overheating. They have rece...
Oldsmobile Intrigue overheating
View Analysis →
Leaking Head Gasket and Overheating Diagnosis
1998 Subaru Legacy
The owner of a 1998 Subaru Legacy wagon reports overheating and gradual coolant loss. A local repair shop has quoted $2500 for head gasket replacement...
Subaru head_gasket overheating
View Analysis →
2000 Dodge Dakota A/C Intermittent Cooling Issue
2000 Dodge Dakota
The owner reports that the A/C in their 2000 Dodge Dakota blows cold air initially but then the cooling fades away after about 5-10 minutes of driving...
Dodge Dakota A/C
View Analysis →
Cooling Fan Sensor Failure Diagnosis for Saturn
unknown Saturn unknown
The owner reports that the Saturn runs hot after sitting still for about 5 minutes. The cooling fan only activates when the A/C is turned on, failing ...
cooling_system temperature_sensor fan_operation
View Analysis →
1999 Chevy Monte Carlo HVAC Flow Intermittent Issue
1999 Chevrolet Monte Carlo
The owner of a 1999 Chevy Monte Carlo reports intermittent airflow issues from the vents. At times, the airflow diminishes significantly, but it will ...
HVAC blower motor intermittent airflow
View Analysis →
1999 Ford Escort Heater System Diagnosis
1999 Ford Escort
The owner of a 1999 Ford Escort reports that while all systems related to the heat function are operational, the vehicle does not blow hot air. They n...
HVAC vacuum lines heat not blowing
View Analysis →
1995 Mazda MPV Only Blowing Warm Air
1995 Mazda MPV
The owner reports that the 1995 Mazda MPV is only blowing warm air from the heater and begins to overheat after about 30 minutes of operation. The veh...
Mazda MPV heating
View Analysis →
2004 Ford Freestar Overheating and Air Pocket Issues
2004 Ford Freestar
The owner of a 2004 Ford Freestar reports overheating issues after replacing the thermostat and flushing the radiator. The vehicle only runs for 2-3 m...
Ford Freestar overheating
View Analysis →
1983 Mercedes Benz 300td Inconsistent Cooling Issue
1983 Mercedes Benz 300td
The owner reports that the air conditioning (AC) system in their 1983 Mercedes Benz 300td is inconsistent. The AC blows cold air when the auxiliary fa...
Mercedes Benz 300td air conditioning
View Analysis →
1996 Ford Ranger Crackling Noise at 30mph+
1996 Ford Ranger
The owner of a 1996 Ford Ranger reports a crackling noise when pressing the accelerator at speeds above 30 mph. Additionally, the vehicle has a deeper...
Ford Ranger U-joint
View Analysis →
1999 Dodge Truck Cooling System Issues
1999 Dodge Ram Truck
The owner reports issues with the air conditioning system in their 1999 Dodge Ram Truck. They describe experiencing uneven temperature control, with t...
Dodge HVAC air conditioning
View Analysis →

Page 4 of 11 - Showing automotive fault analysis cases